Announcement

Collapse
No announcement yet.

206 2.0 hdi running issues.

Collapse
X
 
  • Filter
  • Time
  • Show
Clear All
new posts

  • [Non Corsa] 206 2.0 hdi running issues.

    so I've just finished what is possibly the worst engine swap in the world. and now the ******* dosent run properly. starts fine on the first turn of the key idles lovely does everything it should. until you attempt to rev it above the 2700/3000 mark and it starts to miss and cuts out. occasionally it will become reluctant to start after a few stalls below are a few videos any suggestions will be greatly appreciated as I have a limited knowledge of DT engines.

    /20141219_152100_zpsncrprrff.mp4]"]http://i354.photobucket.com/albums/r425/fiestaman91/Mobile%20Uploads/20141219_152100_zpsncrprrff.mp4][/url]
    /20141219_151608_zpszmzf3xkc.mp4]"]http://i354.photobucket.com/albums/r425/fiestaman91/Mobile%20Uploads/20141219_151608_zpszmzf3xkc.mp4][/url]

    kieran
    Take a look, Its old and rusty[URL="http://www.thecorsa.co.uk/projects-builds/182-zetec-powered-mk1-fiesta.html"]
    http://www.thecorsa.co.uk/projects-builds/182-zetec-powered-mk1-fiesta.html[/URL]

  • #2
    Was it running 100% before it was removed?
    EML on when it's revved like that?
    Does it use a MAF? If so, check the wiring there
    Possibly the diesel pump timing has been knocked out?

    Comment


    • #3
      as far as I've been told the donor engine was a good runner. the previous engine ran ok just had a failing HG and blow turbo seal. no EML. does have a MAF all the wiring seems ok i would assume if it was that i would get a EM light. I've had issues with diesel pump timing before on another motor and can't see it being that as the symptoms are different although i will check tomorow just to rule that out.
      Take a look, Its old and rusty[URL="http://www.thecorsa.co.uk/projects-builds/182-zetec-powered-mk1-fiesta.html"]
      http://www.thecorsa.co.uk/projects-builds/182-zetec-powered-mk1-fiesta.html[/URL]

      Comment


      • #4
        Not familiar with pug diesel's but are the injectors coded

        Comment


        • #5
          Originally posted by craig55 View Post
          Not familiar with pug diesel's but are the injectors coded
          not as far as I'm aware. donor engine came with everything except alternator and PS pump. so the fuel pump injectors ect are all the originals on from the donor engine.
          Take a look, Its old and rusty[URL="http://www.thecorsa.co.uk/projects-builds/182-zetec-powered-mk1-fiesta.html"]
          http://www.thecorsa.co.uk/projects-builds/182-zetec-powered-mk1-fiesta.html[/URL]

          Comment


          • #6
            So if they are they won't pair with the cars ecm which may cause symptoms you have

            Comment


            • #7
              The egr on these can cause running problems to

              Comment


              • #8
                fixed it today. turned out to be a dodgy fuel filter.. swapped them over and it runs like dream!
                Take a look, Its old and rusty[URL="http://www.thecorsa.co.uk/projects-builds/182-zetec-powered-mk1-fiesta.html"]
                http://www.thecorsa.co.uk/projects-builds/182-zetec-powered-mk1-fiesta.html[/URL]

                Comment

                Working...
                X